• Mechanical Properties Of Structural Concrete Containing

    Mechanical Properties Of Structural Concrete Containing

    Fine gravel 121 2749 2661 2693 13367 179 Coarse sand 097 2469 2411 2434 15915 Fine sand 009 2566 2560 2563 16192 312 Sludge from the marble extraction industry The tests on sludge from the marble extraction industry SME were performed at the facilities of

  • Utilization Of Tannery Shredded Waste As Fine

    Utilization Of Tannery Shredded Waste As Fine

    Fine aggregate is an integral part in concrete Due to increase in the construction activities the requirement of fine aggregate is more In other hand tannery waste is abundant in nature a proper replacement of tannery waste over the fine aggregate will not only reduce the tannery waste but also reduce demand for fine aggregate

  • Textile Mill Sludege As Fine Aggregate In Concrete

    Textile Mill Sludege As Fine Aggregate In Concrete

    The replacement of fine aggregate with sludge in conventional concrete mix affects workability and density of concrete The compressive strength gradually reduces with replacement and later it falls below desired value when fine aggregate replaced by textile mill sludge is beyond 32 The fly ash is added to replace cement along with 32 sludge

  • Experimental Investigations On Concrete By Using

    Experimental Investigations On Concrete By Using

    The most commonly used fine aggregate is rive sand Nowadays river sand availability is Lamara Mohamed effect of marble powder on the properties of self compacting sand concrete the Open Construction and 52529 4 Bahar Demirel the effect of using waste granite sludge powder as fine sand on the mechanical propertoies

  • Partial Replacement Of Cement With Marble Powder In Concrete

    Partial Replacement Of Cement With Marble Powder In Concrete

    The coarse aggregate fine angular sharpened edges aggregates were available from local sources Water Potable water used for mixing and curing purposes Preparing of concrete and for this purpose used in the Water cement ratio is WC of 052 52 water range 6 to 75PPM Marble powder The marble dust is obtained from RAK ceramics

  • Investigation On Strength Properties Of Concrete With

    Investigation On Strength Properties Of Concrete With

    large number of marble dust and granite powder is generated in natural stone processing plants with an important impact on environment and humans This project describes the feasibility of using the marble sludge and granite powder in concrete production as partial replacement of cement and fine aggregate

  • An Experimental Investigation On Mechanical

    An Experimental Investigation On Mechanical

    sieve and finally the waste marble dust WMD was obtained to be used in the experiments as fine sand aggregate The maximum size of aggregates used was 16mm The density of coarse and fine aggregates from the 04mmriver sandand 4 16 mm river aggregates group were 2780 and 2730 kgm3respectively In concrete mix proportioning

  • An Experimental Investigation On Utilizations Of Marble

    An Experimental Investigation On Utilizations Of Marble

    The use of marble dust in construction is cost effective because marble dust is available free of cost REFERENCES Hameed M S and Sekar A S S Properties of Green Concrete Containing Quarry Rock Dust and Marble Sludge Powder as fine aggregate ARPN Journal of Engineering and Applied Sciences Vol 4 No 4 June 2009

  • Durability Of Concrete Made With Marble Dust As Partial

    Durability Of Concrete Made With Marble Dust As Partial

    Further marble dust can be used as filler partial replacement of cement as well as partial and full replacement of fine aggregate in mortar as well as in concrete production Thus various investigations have been carried out to utilize such waste product in maintaining or

  • Concrete Properties Containing Fine Aggregate Marble

    Concrete Properties Containing Fine Aggregate Marble

    The rapid growth of the marble industry introduces concerns regarding the negative impact of marble quarrying on the environment because the cutting of marble creates sludge The incorporation of marble sludge powder into concrete and cementbased products would make significant environmental and economic contributions This study aims to develop a concrete mixture with maximum marble

  • An Experimental Investigation Of Partial Replacement Of

    An Experimental Investigation Of Partial Replacement Of

    This project describes the feasibility of using the marble sludge dust in concrete production as partial replacement of fine aggregate In INDIA the marble and granite stone processing is one of the most thriving industry the effects if varying marble dust contents on the physical and mechanical properties of fresh and hardened concrete have

  • Green Cement For Sustainable Concrete Using Marble

    Green Cement For Sustainable Concrete Using Marble

    was also found that waste sludge up to 9 could effectively be used as an additive material in cement To avoid the pollution and reuse the waste material the present study is carried out As the properties are as good as the sand the marble sludge powder and quarry dust is used as fine aggregate in the cement concrete

  • Properties Of Hardened Concrete Produced By Waste

    Properties Of Hardened Concrete Produced By Waste

    Sand As Fine Aggregate Without Waste Marble It Is Observed That Mix Containing 40 Sand 40 Marble Sludge Powder 20 Quarry Rock Dust Had The Best Compressive Strength And Mix Containing 50 Quarry Rock Dust 50 Marble Sludge Powder And 20 Sand 40 Quarry Rock Dust 40 Marble Sludge Powder Had The Best Values For Split Tensile Strength Of

  • Partial Replacement Of Fine Aggregate By

    Partial Replacement Of Fine Aggregate By

    In natural stone processing plants large amounts of marble dust are generated with an important impact on environment and humans This project describes the feasibility of using the marble sludge dust in concrete production as partial replacement of fine aggregate In INDIA the marble and granite stone processing is one of the most thriving

  • Green Cement For Sustainable Concrete Using Marble

    Green Cement For Sustainable Concrete Using Marble

    was also found that waste sludge up to 9 could effectively be used as an additive material in cement To avoid the pollution and reuse the waste material the present study is carried out As the properties are as good as the sand the marble sludge powder and quarry dust is used as fine aggregate in the cement concrete

  • Salvage Of Ceramic Waste And Marble Dust For

    Salvage Of Ceramic Waste And Marble Dust For

    This paper presents the feasibility of the substitution of ceramic waste powder for cement and marble dust for fine aggregates to achieve economy and environment saving Concrete is the most widely used construction material in civil engineering industry throughout the world because of its high structural strength and stability where the fine

  • An Experimental Investigation On Utilizations Of Marble

    An Experimental Investigation On Utilizations Of Marble

    The use of marble dust in construction is cost effective because marble dust is available free of cost REFERENCES Hameed M S and Sekar A S S Properties of Green Concrete Containing Quarry Rock Dust and Marble Sludge Powder as fine aggregate ARPN Journal of Engineering and Applied Sciences Vol 4 No 4 June 2009

  • Pdf Quot Green Concrete Using Industrial Waste Of Marble

    Pdf Quot Green Concrete Using Industrial Waste Of Marble

    From the above study it is concluded that the quarry rock dust and marble sludge powder may be used as a replacement material for fine aggregate The replacement of fine aggregate with 50 marble sludge powder and 50 Quarry rock dust Green concrete gives an excellent result in strength aspect and quality aspect

  • Pdf Marble Waste Opportunities For Development Of Low

    Pdf Marble Waste Opportunities For Development Of Low

    Waste management is a fundamental component to any manufacturing or production enterprise It is estimated that there are million tons of quarrying waste are produced in each year Although a portion of this waste may be utilized onsite such as for

  • Review Paper On Partial Replacement Of Fine

    Review Paper On Partial Replacement Of Fine

    stated that Limestone waste and marble powder can be used in concrete as partial replacement to fine aggregate product during the rocks in rubble crusher units Waste marble powder WMP is an inert material which is obtained as an industrial by product during sawing shaping and

  • Pdf Literature Review On Properties Of Geopolymer

    Pdf Literature Review On Properties Of Geopolymer

    Fig10 Compressive strength values for pavers 28 IXWASTE MARBLE SLUDGE Waste marble sludge was used as fine aggregates by Nezih Kamil Salihoglu et al 29 The compressive strength obtained was high The compressive strength of the sample containing fly ash and NaSilNaOH was 16 MPa and it increased to 30 MPa when marble sludge was added

  • O U R N A L Ofw International Journal Of Waste Resources

    O U R N A L Ofw International Journal Of Waste Resources

    Also the cutting waste of marble sludge will use as a filler material instead of fine aggregate in concrete production Yldz 19 evaluated marble dust and waste parts the availability of roadbuilding They said that in road construction